Marineland Magnum 350 User Manual download pdf

MAGNUM 350 &

MAGNUM 350 BIO-PRO SYSTEM

NVERTIBLE

NISTER

LTERS

IMPORTANT SAFEGUARDS

WARNING: To guard against injury, basic safety precautions should be observed, including the following.

READ AND FOLLOW ALL

SAFETY INSTRUCTIONS

DANGER: T

o avoid possible electric shock, special care should be taken in the use of aquarium equipment.

For each of the following situations, do not attempt repairs yourself. Retur

n the appliance to an authorized

service facility for service or discard the appliance.

1. A. If the appliance falls into the water, DON’T reach for it. First unplug it and then retrieve it.

If electrical components of the appliance get wet, unplug the appliance immediately

B. If the appliance shows any sign of abnormal water leakage, immediately unplug from the power source.

Carefully examine the appliance after installation. It should not be plugged in if there is water on parts not

intended to be wet.

Do not operate any appliance if it has a damaged cord or plug, or if it

is malfunctioning or if it is dropped or damaged in any manner.

E. To avoid the possibility of the appliance plug or receptacle getting wet,

position aquarium stand and tank to one side of a wall mounted receptacle

to prevent water from dripping onto the receptacle or plug. A “drip loop,”

shown in the figure at right, should be arranged by the user for each cord

connecting an aquarium appliance to a receptacle. The“drip loop” is that

par

t of the cord below the level

of the receptacle or the connector

, if an

extension cord is used, to prevent water from traveling along the cord

and coming in contact with the receptacle. If the plug or receptacle does

get wet, DON’T unplug the cord. Disconnect the fuse or circuit breaker that

supplies power to the appliance. Then unplug and examine for presence

of water in the receptacle.

2. Close supervision is necessary when any appliance is

used by or near children.

o avoid injur

, do not contact moving parts or hot parts such as heaters, reflectors, lamp bulbs, etc.

4. Always unplug an appliance from an outlet when not in use, before putting on or taking off parts, and before

cleaning. Never yank cord to pull plug from outlet. Grasp the plug and pull to disconnect.

Do not use an appliance for other than intended use. The use of attachments

not recommended or sold by the

appliance manufacturer may cause an unsafe condition.

6. Do not install or store the appliance where it will be exposed to the weather or to temperatures

below freezing.

Make sure an appliance mounted on a tank is securely installed before operating it.

Read and observe all the important notices on the appliance.

9. If an extension cord is necessary, a cord with a proper rating should be used. A cord rated for less amperes

or watts than the appliance rating may overheat. Care should be taken to arrange the cord so that it will not

be tripped over or pulled.

This appliance has a polarized plug (one blade is wider than the other). As a safety feature, this plug will fit in

a polarized outlet only one way. If the plug does not fit fully in the outlet, reverse the plug. If it still does not fit,

contact a qualified electrician. Never use with an extension cord unless plug can be fully inserted. Do not

attempt to defeat this safety feature.

SAVE THESE INSTRUCTIONS

AQUARIUM

APPLIANCE

POWER CORD

DRIP

LOOP

arts Diagram & Identification

(800) 322-1266 www.marineland.com

Troubleshooting Guidelines

05/07 P/N 11958

LIMITED WARRANTY

Within three years from the date of original purchase, Marineland Aquarium Products will repair or replace,

at its option, any MAGNUM 350 or MAGNUM 350 BIO-PRO Canister Filter which is deemed defective in

workmanship or materials. Please return the unit, together with proof of date of purchase:

Call (800) 322-1266 for return authorization and shipping address.

Damage or injuries resulting from negligence or misuse are not covered by this warranty. Incidental

or consequential damages are specifically excluded*. This warranty gives you specific legal rights.

You may also have other rights which vary from state to state.

*Because some states do not allow the exclusion of incidental or consequential damages, this exclusion may not apply to you.

Replacement Par

ts List

Questions or Missing Parts: Call Customer Service (800) 322-1266

(M-F 8am to 5pm,

Eastern Time)

Model# Magnum 350

IF flexible hose kinks or collapses.

eposition filter to avoid loops and deep curves in

hose. Or cut hose to fit.

F Intake Tube is too long.

Cut to desired length and reinstall.

IF Intake Tube is too short.

se extension tube provided. Or purchase

/4”

diameter extension from aquarium dealer (PA1341).

IF unit will not pump and/or

air won't evacuate from Canister.

Be sure Impeller Assembly and Housing are properly

nstalled. Also Check Sleeve, Carbon/Media Container,

Micron Cartridge for clogging - clean or replace. Try to

Burp" Canister. If air remains trapped in Canister

after startup, lift Canister off motor (do not discon-

nect Canister cover), hold lower than aquarium, and

ilt Canister until air has evacuated. Restart. Also

make certain that "OUT" port inside Canister Cover is

itted over Impeller Exhaust Tube inside Canister.

Make certain that "OUT" port on top of Canister Cover

is connected to Outlet Hose and Tube. Check to see

hat end of Outlet Tube and Diffuser are under water.

Correct any loops, kinks or deep curves in hose.

F filter makes excessive

noise or stops abruptly.

Rinse Canister, Impeller Assembly and Impeller Sump

o remove gravel or carbon obstructions. Also rinse

Carbon /Media Container thoroughly.

F pumping slows or stops gradually.

Inspect hoses for dirt blocking flow. Clear with Flexi-

Brush accessory (PA0554). Clean or replace Filter

leeve, Carbon/Media Container, Micron Cartridge.

MAGNUM CANISTER

•

Replace Filter Media every 2-4 weeks.

Black Diamond Premium Activated Carbon

is available at your local Marineland dealer.

•

lean Impeller monthly.

•

lean Intake Tube monthly.

•

lean Micron Cartridge Regularly (Rinse only)

UICK-DISCONNECT DOUBLE VALVES

•

eep valves clean at all times

•

Periodically remove coupling barrel to clean

grooves and O-rings.

•

Inspect O-rings for wear.

(To replace, request part #PR1450.)

•

When servicing the Magnum, turn valves off and

disconnect the valve halves. Then lift the

Magnum’

s canister from the motor

, leaving its

over in place. Reconnect by reversing steps.

BIO-WHEEL PRO

•

nce every month, gently brush the BIO-Wheel’s

housing and cover to remove any mineral or

salt crust.

•

Once every month, clean the spray bar with rigid

brush. To do so, shut off the water supply, release

the clips and remove the spray bar.

•

Every three months, disconnect all fittings and

clean the inside hoses with a 48-inch Flexi-Brush.

nspect O-rings for damage and replace if

ecessary.

•

A properly cultured BIO-Wheel is brown or

discolored, and may rotate irregularly

This is nor

mal. If it becomes so heavily cultured that it no

longer rotates, gently rinse its surface to remove

the heaviest buildup. Use only room-temperature

dechlorinated water.

IF air accumulates in Canister during operation.

Move Intake away from airstone bubbles or other air

ource. Also check position of hoses and Hose

Retainer Bands to ensure that air is not being sucked

n through hose connections.

IF leakage occurs at hose connections.

Position hose and/or Snapper Clamps properly. Or

einstall with light coating of silicon lubricant.

IF leakage occurs along rim of Canister Cover.

Check to see that O-Ring is positioned properly. If

O-Ring is damaged, replace immediately. Wash

O-Ring seal area thoroughly. If leak persists, try

ubricating O-Ring lightly with silicon lubricant.

350 BIO-WHEEL PRO

If water does not flow from the BIO-Wheels.

nspect the Spray Bars for obstruction or buildup.

Also, make sure that the Magnum is plugged in and

hat its valves are open. Lastly, check its impeller

system for grit or debris.

If water flow is reduced or the BIO-Wheel

will not rotate. Check the Magnum media for

heavy clogging. If the media is clogged, change it

or clean it. If it’s not clogged, try cleaning and/or

eadjusting the Spray Bar

. Also try cleaning or

replacing the BIO-Wheel’s bearings.

IMPORTANT:

Always unplug Canister

Filter before inspecting

or disassembling for

ny reason.

For Optimum Performance

NOTE:

Black Diamond Premium activated Carbon and

Bonded Filter Sleeve are not considered a replacement

parts. They are available at your Marineland dealer.

O-Rings Only

+ O-Rings

KEY ITEM DESCRIPTION ITEM NO.

1 Clip & Pin Set, Pkg- 4 PR1437

Canister Cover with Intake Diffuser PR1412

3 O-Ring Cover Seal PR1413

4 Rubber Gasket Set (2 large & 1small) PR1414

5 Carbon/Media Container PA0145

6 Exhaust Tube PR1430

7 Impeller Housing PR1474

8 Impeller & Shaft Assy. w/out Magnet PR1472

9 Magnet PR1470

10 Canister with Mounted Clips PR1476

11 Sump Cap PR1480

12 Motor Assembly PC 350 PR1477

13 Stabilizer Leg PR1479

14 Tube Retainer Bracket PR1404

15 Intake Tube with Strainer PR1402

16 Outlet Tube with Split Flow Diffuser PR1401

KEY ITEM DESCRIPTION ITEM NO.

17 Suction Cups - 4 PR11979

Micron Cartridge PA0140

19 Rigid Core for Micron Cartridge PR1420

20 Silicone Lubricant PR1590

21 Snapper Clamps - 4 PR11941

BIO-Wheel PRO Replacement Parts List

22 BIO-Wheel Assembly PR2002

23 Spray Bar Assembly PR2006

24 Barbed Tee PA2010

25 Tee Connector w/O-Rings PR2035

26 O-Rings - BIO-Wheel PRO - Pkg. 4 PA2045

27 Barings - Pkg. 2 PR2001

28 Nut & Screw - Pkg. 2 (L-R Set) PA2007

29 Connector Clips - Pkg. 2 PR2004

BIO-Wheel PRO

1 2

Summary of Contents

Page 1 - SAVE THESE INSTRUCTIONS

MAGNUM 350 &MAGNUM 350 BIO-PRO SYSTEMCONVERTIBLECANISTERFILTERSIMPORTANT SAFEGUARDSWARNING: To guard against injury, basic safety precautions shou

Page 2 - CONSERVEZ CES INSTRUCTIONS

GARANTÍA LIMITADA Por un período de tres años desde la fecha de compra original, MarinelandAquarium Products reparará o reemplazará, a su elección, cu

Marineland Magnum 350 User Manual

Browse online or download User Manual for Above ground pool accessories Marineland Magnum 350. important safeguards read and follow all safety

Summary of Contents

More documents for Above ground pool accessories Marineland Magnum 350

Comments to this Manuals

Marineland Magnum 350 User Manual

Browse online or download User Manual for Above ground pool accessories Marineland Magnum 350. important safeguards read and follow all safety

Summary of Contents

More documents for Above ground pool accessories Marineland Magnum 350

Comments to this Manuals

Related products and manuals for Above ground pool accessories Marineland Magnum 350